Please wait a minute...
 
最新公告: 重要提醒:骗子冒充编辑部要求加作者微信,谨防上当!   关于暑假、寒假期间版面费发票及期刊样刊延迟邮寄的通知    
现代化工  2018, Vol. 38 Issue (7): 162-166    DOI: 10.16606/j.cnki.issn0253-4320.2018.07.037
  科研与开发 本期目录 | 过刊浏览 | 高级检索 |
活性炭/聚氨酯海绵的制备工艺与吸附性能
林云, 梁晓怿, 李松原, 吕妍
华东理工大学化工学院, 上海 200237
Preparation of activated carbon/polyurethane sponge and its adsorption property
LIN Yun, LIANG Xiao-yi, LI Song-yuan, LV Yan
School of Chemical Engineering, East China University of Science and Technology, Shanghai 200237, China
下载:  PDF (2489KB) 
输出:  BibTeX | EndNote (RIS)      
摘要 利用物理负载法制备活性炭/聚氨酯海绵(AC/PU)复合材料,探讨了制备工艺中稀释剂挥发温度、时间和胶液质量分数对材料结构的影响,以及材料结构对吸附性能的影响。结果表明,稀释剂挥发温度和时间对材料结构没有明显影响;胶液质量分数越大,材料的活性炭负载量越大。材料负载量越大,床层压降越大,但对活性炭的比表面积没有明显影响。胶液质量分数为50%时,单位质量的聚氨酯海绵的负载量为13~15 g/g;当风速达到12 m/s时,压降浮动范围为0.4~0.5 kPa,压降降低了17%~33%。沥青基活性炭海绵平均吸附量为0.092 4 g/g。吸附量降低了32.2%,与粉末活性炭海绵(PAC/PU)相比,穿透吸附量增加了2.37倍。
服务
把本文推荐给朋友
加入引用管理器
E-mail Alert
RSS
作者相关文章
林云
梁晓怿
李松原
吕妍
关键词:  活性炭  海绵  VOCs  吸附  固定床    
Abstract: The activated carbon/polyurethane sponge (AC/PU) composites are prepared by physical load method.The effects of the volatilization temperature and time of diluents,and the mass concentration of glue during preparation process on the structure of the prepared composites are investigated.As well,the effects of the structure of the prepared composites on the adsorption performance are also studied.The results show that neither volatilization temperature nor time of diluents has significant effect on the composites' structure.The larger the mass concentration of the glue,the larger the activated carbon load amount,and then the greater the bed pressure drop,but the specific surface area of activated carbon is not affected significantly.When the mass concentration of glue is 50%,the load capacity of polyurethane sponge is 13-15 g/g of activated carbon.When the wind speed reaches 12 m·s-1,the pressure drop of the bed fluctuates in the range of 0.4-0.5 kPa.Compared to the fixed-bed,the pressure drop in this bed is 17%-33% less.The average adsorption capacity for asphalt-based activated carbon sponge is 0.092 4 g·g-1,with a drop of 32.2%.The penetration adsorption capacity of as prepared AC/PU increases 2.37 times compared with the powder activated carbon polyurethane sponge (PAC/PU).
Key words:  activated carbon    sponge    VOCs    adsorption    fixed-bed
收稿日期:  2017-12-22      修回日期:  2018-05-08           出版日期:  2018-07-20
TQ106  
通讯作者:  梁晓怿(1973-),男,博士,教授,硕士生导师,研究方向为炭材料,通讯联系人,xyliang@ecust.edu.cn。    E-mail:  xyliang@ecust.edu.cn
作者简介:  林云(1992-),女,硕士研究生,研究方向为炭材料,1083153164@qq.com
引用本文:    
林云, 梁晓怿, 李松原, 吕妍. 活性炭/聚氨酯海绵的制备工艺与吸附性能[J]. 现代化工, 2018, 38(7): 162-166.
LIN Yun, LIANG Xiao-yi, LI Song-yuan, LV Yan. Preparation of activated carbon/polyurethane sponge and its adsorption property. Modern Chemical Industry, 2018, 38(7): 162-166.
链接本文:  
http://www.xdhg.com.cn/CN/10.16606/j.cnki.issn0253-4320.2018.07.037  或          http://www.xdhg.com.cn/CN/Y2018/V38/I7/162
[1] 银爱君,邓起发.室内空气污染的来源及控制措施[J].环境与发展,2010,22(3):102-104.
[2] 伊冰.室内空气污染与健康[M].北京:化学工业出版社环境科学与工程出版中心,2003.
[3] Mumtaz M M,Ray M,Crowell S R,et al.Translational research to develop a human PBPK models tool kit-volatile organic compounds (VOCs)[J].Journal of Toxicology & Environmental Health Part A,2012,75(1):6-24.
[4] Wang F,Li C,Liu W,et al.Effect of exposure to volatile organic compounds (VOCs) on airway inflammatory response in mice[J].Journal of Toxicological Sciences,2012,37(4):739-48.
[5] Purcell R Y,Shareef G S,Corporation J.Handbook of control technologies for hazardous air pollutants[M].United States:Science Information Resource Center,1900.
[6] Vermeulen N P E,Coleman M D.Environmental toxicology and pharmacology publishes the results of studies concerning toxic and pharmacological effects of (human and veterinary) dru[J].Environmental Toxicology & Pharmacology,2009,27(2):293-297.
[7] Jones A P.Indoor air quality and health[J].Atmospheric Environment,1999,33(28):4535-4564.
[8] 银爱君,邓起发.室内空气污染的来源及控制措施[J].环境与发展,2010,22(3):102-104.
[9] 陈清,余刚,张彭义.室内空气中挥发性有机物的污染及其控制[J].上海环境科学,2001(12):616-620.
[10] 陈根年.密闭环境中有害气体控制技术[J].舰船科学技术,1995(1):62-65.
[11] 冯林平,陶冶,刘培英.纳米TiO2光催化材料在潜艇舱室空气净化中的应用前景[J].舰船科学技术,2004,26(6):70-72.
[12] Song Y H,Kim S J,Choi K I,et al.Effects of adsorption and temperature on a nonthermal plasma process for removing VOCs[J].Journal of Electrostatics,2002,55(2):189-201.
[13] Chiang Y C,Chiang P C,Huang C P.Effects of pore structure and temperature on VOC adsorption on activated carbon[J].Carbon,2001,39(4):523-534.
[14] Khan F I,Ghoshal A K.Removal of volatile organic compounds from polluted air[J].Journal of Loss Prevention in the Process Industries,2000,13(6):527-545.
[15] 汤华民,李江存,舒一兰.活性炭材料在空气净化中的应用[C].公共安全中的化学问题研究进展,2011:174-178.
[16] 李守信,金平,张文智,等.采用活性炭纤维吸附装置回收VOC的优点分析[J].化工环保,2004,24(s1):274-276.
[17] 郭丰涛,刘忠权,陈国根,等.核潜艇舱室空气组分容许浓度GJB 11-84的修订[J].海军医学杂志,1999,20(1):19-23.
[18] 近藤精一.吸附科学[M].李国希,译.第2版.北京:化学工业出版社,2005:103-105.
[19] 宋颖韬,党明岩,王鼎雯.活性炭固定床吸附苯蒸汽的数值模拟[J].沈阳理工大学学报,2017,36(2):88-92.
[20] 吴红亮.活性炭吸附分离苯蒸气的数学模拟[D].大连:大连理工大学,2011.
[1] 陈川, 薛叙明. α-蒎烯固定床加氢制顺式蒎烷[J]. 现代化工, 2018, 38(9): 110-112,114.
[2] 谷麟, 杨文昊, 崔建军, 张卫国, 闻海峰, 陶红. 尿素活化污泥制备生物质活性炭的研究[J]. 现代化工, 2018, 38(9): 118-121,123.
[3] 张耀日, 霍志萍, 张丽娟, 冯晴, 臧甲忠, 于海斌. SSZ-13分子筛合成及应用进展[J]. 现代化工, 2018, 38(9): 54-59.
[4] 关丽萍. 挥发性有机物(VOCs)末端控制技术实践与发展综述[J]. 现代化工, 2018, 38(9): 64-67.
[5] 李松原, 梁晓怿, 林云, 吕妍, 刘馥雯. 活性炭流化床对VOCs的吸附条件及吸附边界曲线的研究[J]. 现代化工, 2018, 38(8): 166-171.
[6] 闫鸿飞. FCC再生器直接燃烧处理VOCs试验研究[J]. 现代化工, 2018, 38(8): 189-192.
[7] 黄斌, 王捷, 傅程, 朱婷婷, 李晓慧, 代亭阁. 油田采出水处理技术研究新进展[J]. 现代化工, 2018, 38(8): 52-57.
[8] 李聪, 钟溢健, 解庆林, 陈南春. 不同吸附材料处理水中砷的效应分析[J]. 现代化工, 2018, 38(7): 21-25.
[9] 王曦, 麦裕良, 张俊杰, 陈佳志, 应家伟, 文明通. MOFs材料对气态硫化合物的吸附研究进展[J]. 现代化工, 2018, 38(7): 62-66.
[10] 张朋飞, 刘欢, 董菲. 重质原油油气冷凝-吸附耦合系统的安全工艺探究[J]. 现代化工, 2018, 38(7): 187-189.
[11] 余亚兰, 尹峰, 唐仕波. 基于微流控法单分散多孔微球的制备及其油吸附性能研究[J]. 现代化工, 2018, 38(6): 136-139.
[12] 李丹阳, 任爱玲, 宋旸. 被动式采样器测定土壤中挥发性有机物的研究进展[J]. 现代化工, 2018, 38(6): 227-232.
[13] 蒋文艳, 张琳叶, 龙建沿, 周昌喜, 廖志飞, 魏光涛. 赤泥基环境修复材料的制备及应用进展[J]. 现代化工, 2018, 38(5): 29-33.
[14] 蒋广安, 赵越, 李宝忠, 郭宏山. 活性炭基催化剂臭氧催化氧化处理酸性大红染料废水[J]. 现代化工, 2018, 38(5): 124-127.
[15] 王振东, 李春虎, 徐国强, 牟新东. Ir-N@C催化剂在选择性制备直链醇中的应用[J]. 现代化工, 2018, 38(5): 134-138.
[1] . [J]. Modern Chemical Industry, 2015, 35(11): 77 -80 .
[2] . [J]. Modern Chemical Industry, 2015, 35(12): 128 -130,132 .
[3] . [J]. Modern Chemical Industry, 2017, 37(6): 103 -0106,108 .
[4] . [J]. , 2003, 23(5): 0 .
[5] . [J]. , 2009, 29(6): 0 .
[6] . [J]. , 2010, 30(3): 0 .
[7] . [J]. , 2010, 30(7): 0 .
[8] . [J]. , 2007, 27(2): 0 .
[9] . [J]. Modern Chemical Industry, 2014, 34(2): 131 -133 .
[10] . [J]. Modern Chemical Industry, 2014, 34(4): 14 -16 .
Viewed
Full text


Abstract

Cited

  Shared   
  Discussed   
京ICP备09035943号-37
版权所有 © 《现代化工》编辑部
本系统由北京玛格泰克科技发展有限公司设计开发 技术支持:support@magtech.com.cn